Burleson · Johnson County
US Automatic Gate Repair in Burleson, TX
US Automatic gate operator repair in Burleson for the battery-driven Patriot and Ranger units on the county acreage and ranch entrances around the newer subdivisions.
- Licensed & Insured
- 16+ Years Experience
- Open 24/7
- Residential & Commercial
What we see on US Automatic gates in Burleson
Beyond Burleson’s new subdivisions, the Johnson County acreage still has long drives and ranch entrances where mains power never reached the gate. That is where US Automatic operators usually sit, running a Patriot or Ranger from a 12-volt battery charged by a solar panel. Like much of Burleson’s equipment, many of these went in during the same growth years, so a lot of batteries are reaching the end of their life around the same time. A gate that has started moving slowly or stalling on cloudy days nearly always points to the battery or the panel rather than the operator.
The first step is a load test of the battery and a check of the panel’s output and angle. A new battery is a fraction of the cost of a new operator, and a panel that has been shaded by growing trees can simply be moved. If the charging side is healthy, attention turns to the control board, the limit settings and the arm linkage, which wears on long ranch gates. For properties along SH 174 and the county roads toward Overbrook Farm, a Ranger HD suits heavier gates better than a lighter Patriot.
Real jobs nearby
Our nearest documented US Automatic jobs to Burleson
US Automatic work our technicians have documented in nearby cities, each shown under the city it was in.
US AutomaticFort Worth, TXresidentialAnother Company Said Replace It. We Refurbished It Instead.
A Fort Worth homeowner had been told the solar operator needed replacing. The board was corroded, the arm needed repair and the gate was leaning — all fixable.
Read the case study
US AutomaticProsper, TXresidentialWe Tested the Bent Arm Before Replacing It
A gate that had not worked in a long time. The battery was flat, and the visibly bent arm was tested on the chance it could be kept.
Read the case study
On video
US Automatic jobs near Burleson on video
Filmed on our own jobs nearby, each marked with its city: Fort Worth (15 mi), Prosper (57 mi).
What usually fails on US Automatic operators
- Battery degradation — the most common cause on solar installs by a wide margin
- Solar panel output loss from shading, dirt or panel angle drift
- Battery controller and charge-path failure
- AC charger or charge-wire faults on AC-charged installs
- Control board damage from lightning and power surges
- Limit switch drift on Patriot units, and limit settings on Ranger control boards
- Gate arm and linkage wear on long driveway gates
US Automatic models we repair in Burleson
Areas we cover in Burleson
- Mistletoe Hill
- Shannon Creek
- Overbrook Farm
- Elk Ridge Estates
- Hidden Vistas
More of our recent gate repair work
Recent gate operator jobs by our technicians across Dallas–Fort Worth.
Customer testimonials
What our customers say
Customers across Dallas–Fort Worth, filmed at their own gates. We bring the same team to Burleson.
US Automatic gate repair in Burleson: questions
Our US Automatic gate in Burleson gets slow in winter. Is it worn out?
Most likely the battery is weakening, and winter exposes it. Shorter days and lower sun mean the panel puts in less charge, and an old battery cannot hold enough to run the gate through a cloudy spell. A load test will confirm it. Replacing the battery, and checking that the panel is clean and facing the sun, usually brings the gate back to normal.
Can a US Automatic operator run from mains power instead of solar in Burleson?
Yes. US Automatic operators always run from their battery, but the battery can be charged by a low-voltage AC charger instead of a solar panel where an outlet is close enough. That suits a gate near the house or a subdivision lot. The repair logic is the same for both setups: check the battery and the charger before condemning the operator.
Every gate service in Burleson
Not a US Automatic? We repair every major operator brand in Burleson, plus sliding, swing, commercial and access control work.
- Gate repair in Burleson
- LiftMaster gate repair in Burleson
- DoorKing gate repair in Burleson
- Elite gate repair in Burleson
US Automatic gate repair near Burleson
Other cities where we have documented US Automatic jobs.
Gate Not Working Right Now?
We answer the phone 24/7. If you are stuck, call and we will talk you through the manual release before anyone arrives. See what counts as a gate emergency.